Cold weather AF problems?

Discussion of all digital SLR cameras under the Minolta and Konica Minolta brands
Forum rules
No more than three images or three external links allowed in any post or reply. Please trim quotations and do not include images in quotes unless essential.
dkloi
Initiate
Posts: 32
Joined: Wed Jun 17, 2009 12:23 am
Location: Glasgow
Contact:

Cold weather AF problems?

Unread post by dkloi »

Anyone seen problems with AF on a lens not working in the cold (not even below freezing) but recovering when back at room temperature? Could this be due to lubricant becoming too viscous or maybe the tolerances just on the wrong side of the distribution curves leading to binding under thermal contraction?

Cheers,
Daniel.
Minolta AF 9000, Dynax 7, KM 7D, Sony A700, A580, A77, NEX-7
http://www.dkloi.co.uk
http://www.360cities.net/profile/daniel-oi
mvanrheenen

Re: Cold weather AF problems?

Unread post by mvanrheenen »

No, never noticed it. I shoot a lot in cold and freezing conditions. Never seen this issue.

You have?
dkloi
Initiate
Posts: 32
Joined: Wed Jun 17, 2009 12:23 am
Location: Glasgow
Contact:

Re: Cold weather AF problems?

Unread post by dkloi »

Yup. Works when at room temperature (or above). Went out today (about 5 deg C) and after about 10 mins the lens starts refusing to AF. After a few more mins, the AF becomes even more sluggish and intermittent. Sometimes it can be "kickstarted" by manually focussing to the approximate focus and then the AF works again for a little bit, then malfunctions again.

Taking it back inside, I try it on a different body, still refusing to AF. After a while after it has warmed up again, it's back to normal operation on both bodies. I go out again into the cold to test my theory, again after a few minutes the AF begins to act up again. Bring back inside, now working again.

Frustrating, especially since I had it repaired twice (took Sony two goes at it before they managed to repair the lens) for the same problem about a year ago, though in that case the AF malfunction was permanent. I do recall the first time the AF went away, I was out in the cold. However it never recovered even when the lens warmed up. After the first two rounds of repairs, I didn't have an opportunity to take it anywhere cold. It's been used during the summer and on the equator. By Sod's law, I would have to find out about the cold weather problem just after the warranty has run out.
Minolta AF 9000, Dynax 7, KM 7D, Sony A700, A580, A77, NEX-7
http://www.dkloi.co.uk
http://www.360cities.net/profile/daniel-oi
User avatar
mikeriach
Imperial Ambassador
Posts: 583
Joined: Sat Feb 02, 2008 11:29 am
Location: Aberdeen

Re: Cold weather AF problems?

Unread post by mikeriach »

Which lenses guys?
All my Sony SLT gear gone. Still got my RX100 though.
User avatar
harveyzone
Oligarch
Posts: 162
Joined: Sun May 20, 2007 11:54 am
Location: Worcestershire, England

Re: Cold weather AF problems?

Unread post by harveyzone »

mikeriach wrote:Which lenses guys?
Yep, and which body too?
--
Tom
dkloi
Initiate
Posts: 32
Joined: Wed Jun 17, 2009 12:23 am
Location: Glasgow
Contact:

Re: Cold weather AF problems?

Unread post by dkloi »

DT 16-50mm SSM on A77 and A700. Took it out on the A77 today (about 8 deg C) but it worked OK. Managed to do some street photography with it, http://www.dkloi.co.uk/?p=999

Image
Image

I even tested out the weather resistance of both lens and body, no problems there. I'm wary taking the lens out when it is colder than 5 deg C lest it break like the first time (around freezing). I've used the Tamron 17-50mm/2.8 down to about -20 deg C and the zoom action did get a bit stiff, but the AF still worked (on the A77).
Minolta AF 9000, Dynax 7, KM 7D, Sony A700, A580, A77, NEX-7
http://www.dkloi.co.uk
http://www.360cities.net/profile/daniel-oi
User avatar
mikeriach
Imperial Ambassador
Posts: 583
Joined: Sat Feb 02, 2008 11:29 am
Location: Aberdeen

Re: Cold weather AF problems?

Unread post by mikeriach »

I've never had any issues with any bodies or lenses at low temps, A700, A580 or A77.
Been out in rain, sleet, snow at least down to -10degC.
Mike
All my Sony SLT gear gone. Still got my RX100 though.
User avatar
Greg Beetham
Tower of Babel
Posts: 6117
Joined: Sun May 27, 2007 3:25 pm
Location: Townsville, Qld. Australia
Contact:

Re: Cold weather AF problems?

Unread post by Greg Beetham »

Does the camera issue an error message when the lens doesn’t focus? Stepper motors are very high torque (rare earth magnets) and quite capable of damaging anything in their path that doesn’t rotate when they do so I’d imagine that the only thing saving the lens internals is a drive belt that slips like a clutch effect when the lens seizes up.
When the AF doesn’t work the MF becomes stiff as well so there is it would seem some kind of thermal binding taking place, either that or there might be lubricant going thixo or sticky in a gear collar, but that seems far fetched too me at only 5°C, most greases won’t be affected until well below freezing.
I would be inclined to suspect a lens element carrier that has to slide back and forth for the focus action and is a very close ‘fit’ in it’s sleeve, probably all it needs is a little graphite powder, but that should have been attended to the last time it was fixed…one would think.
Greg
User avatar
harveyzone
Oligarch
Posts: 162
Joined: Sun May 20, 2007 11:54 am
Location: Worcestershire, England

Re: Cold weather AF problems?

Unread post by harveyzone »

I use this combination (A77/16-50) and have not noticed a problem, although have not done that much outdoors since it turned colder.

Could it be a battery issue?
--
Tom
dkloi
Initiate
Posts: 32
Joined: Wed Jun 17, 2009 12:23 am
Location: Glasgow
Contact:

Re: Cold weather AF problems?

Unread post by dkloi »

It's an SSM lens so it's not a problem with the body screwdriver AF system. Battery was fully charged. It wouldn't work on the A700 (which was at room temperature and with a different battery).

One hypothesis is that the clutch disengaging the focus ring could be having problems. If it doesn't disengage, the AF ring motor probably doesn't have enough torque to turn the entire system.

I foresee more long phonecalls to SSC Pencoed.
Minolta AF 9000, Dynax 7, KM 7D, Sony A700, A580, A77, NEX-7
http://www.dkloi.co.uk
http://www.360cities.net/profile/daniel-oi
User avatar
Greg Beetham
Tower of Babel
Posts: 6117
Joined: Sun May 27, 2007 3:25 pm
Location: Townsville, Qld. Australia
Contact:

Re: Cold weather AF problems?

Unread post by Greg Beetham »

Ok it’s SSM but that only means it’s immune from being damaged by the body focus motor after it seizes up, (I’m not familiar with the Sony 16-50) but most likely it’s some kind of thermal binding somewhere internally as it only happens when the temperature changes, when it gets cold. No error report from the camera I assume.
I think the ball is still in Sony’s court from the last time it was repaired regardless if it’s out of warranty as the lens is still obviously not fixed, it should not freeze up at 5°C.
Greg
dkloi
Initiate
Posts: 32
Joined: Wed Jun 17, 2009 12:23 am
Location: Glasgow
Contact:

Re: Cold weather AF problems?

Unread post by dkloi »

No error reports on either body. Just a failure for the lens to AF. The focus ring clutch is still engaged so I can move the focus until the AF point goes green and occasionally this is enough for the AF to revive temporarily (keeping the shutter button pressed).

These (peizoelectric) ultrasonic ring motors probably don't have as much torque as conventional electromagnetic motors, hence if there is any binding due to mismatched thermal contraction, it may be enough to cause it to seize up. However the fact that I can still use the focus ring with the shutter button depressed means that the camera/lens is not disengaging the focus ring clutch which could be the root cause.

More investigation awaits colder weather (unless I decide to stick the camera in the fridge or freezer). Of course, if I send it into SSC they won't be able to reproduce the problem without similarly cooling the lens.
Minolta AF 9000, Dynax 7, KM 7D, Sony A700, A580, A77, NEX-7
http://www.dkloi.co.uk
http://www.360cities.net/profile/daniel-oi
User avatar
Greg Beetham
Tower of Babel
Posts: 6117
Joined: Sun May 27, 2007 3:25 pm
Location: Townsville, Qld. Australia
Contact:

Re: Cold weather AF problems?

Unread post by Greg Beetham »

I got the impression from the original description that the lens mechanically binds up and becomes stiff to move. But it seems that the MF remains free except that the collar attempts to turn during AF when it shouldn’t, is that right?
If the MF focus collar disconnects for reduced load (accidental hand pressure as well for instance) during AF under normal conditions and then doesn’t when it gets cold then it’s most likely something to do with that part of the mechanism that disconnects/reconnects the internal AF from the external MF collar. Some lenses do disconnect and some don’t, in my set of lenses the MF collar rotates on the 17-35, 28-75 and 18-200 during AF but doesn’t on the 100-300apod and 24-105.
I have never seen an exploded view of the way that works and there are any number of possible design approaches for implementing the disconnect/reconnect feature, there doesn’t seem to be any way to get exploded views of lenses so one could get a good idea on the design and function etc.
But in any case I think the bottom line is your lens wasn’t fixed properly when it was sent in the last time for repair, so it needs to go back and get fixed properly.
Greg
dkloi
Initiate
Posts: 32
Joined: Wed Jun 17, 2009 12:23 am
Location: Glasgow
Contact:

Re: Cold weather AF problems?

Unread post by dkloi »

Just an update on this issue. I sent in my lens to SCS for repair. Got a nice surprise when they sent me a replacement lens as they didn't have the parts to fix the old one. So a thumb's up to Sony for rectifying the situation even though the lens was out of warranty. It was a pity the lens had AF problems in the first place and took a few attempts at repair but hopefully the new lens will be fully functioning (fingers crossed).

Cheers,
Daniel.
Minolta AF 9000, Dynax 7, KM 7D, Sony A700, A580, A77, NEX-7
http://www.dkloi.co.uk
http://www.360cities.net/profile/daniel-oi
Post Reply

Who is online

Users browsing this forum: No registered users and 4 guests